Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Quote:
but that 472 sounds like fun! |
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
2 Attachment(s)
Well, the headers will need some work. Driver's side fits fine, but the passenger's side the EGR and number 6 tube hit the frame. Bogus.
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
2 Attachment(s)
Too bad I'm not ready for the turbo (not enough funds). The manifolds fit fine like this...
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
why not mount the headers like that now and build your y pipe and turbo flange. then just run the exhaust down from the turbo flange. Then when you get a turbo the header work is done.
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Quote:
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
I've got the piping coming already, so that's most likely what will be done. I will trim off the EGR tubes and patch them up, then start with the routing.
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Looks good
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
4 Attachment(s)
I got the EGR tubes cut off and patched. I got my flanges and mandrel bends in stock now too.
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Sweet! Man I'm so excited about this build!
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
2 Attachment(s)
I started piecing a few things together for the exhaust. If I were to try to do the hot pipes right now, I'm just not confident about placement without having the turbo in my hands, so a temporary conventional duals will be used until the turbo install starts later this year.
I had to clearance the passenger frame rail with a few small arcs. Driver's side was close, but no cuts. |
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Fuel pump bolted to the frame, grounded, power wire ran to the front. New gas lines bent, bolted to the frame, ran up the firewall. Starter installed. Rerunning many many wires...
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
It'll get there, just keep at it.
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Keeping at it. Wired the fuel pump up to the battery for a quick test to make sure fuel was getting to the front (success!). Fixed the broken vacuum port for the power brakes and T'ed over to the vent control ball for the HVAC control. Rewired the feed to the starter/alternator/ground and tested turning it over (success!). Next is connecting the fuel rails and throwing the ECU/harness into the engine bay and start connecting things.
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
1 Attachment(s)
ECU and harness about 80 percent installed.
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Sweet man, so when do you think you will be driving this thing?
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Coming along real well
Posted via Mobile Device |
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
2 Attachment(s)
Quote:
Custom throttle cable installed and temporary intake idea thrown in place. I'll shorten up one leg of the 90 degree bend and lengthen the other to move it away from the radiator to clear the fans. |
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Cool man! I bet you will be glad to be driving Mr.Green Jeans again..
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
OK, so technically the engine would run right now, but I can't start it until I fill it up with fluids and put an oil filter on it. I need to form one more transmission line to the radiator... I still need to wire up the fans and mount them as well. I will need to rewire 2 injectors as I must have pulled on them too hard while doing the fuel lines and the wires came right out of the clips...
Fuel lines went in today and pressure tests good at key on position. Finished up the cooling system hose routing for the steam line return to the old radiator heater return spot. He's getting there!!! The next day or two I should have an initial test drive under my belt and be working out any bugs. |
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Hell yeah, your close now!
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Looking good, keep at it. I know how it feels to be so close to driving it. I just need gas and to get my drive way clear of side jobs, LOL.
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Well I went and bought all of the little things to finish it up in the morning, but we went to Furious 7 and then to a car show with the Bad Boyz Mustang Club of Iowa and then I had to mow which pretty much killed off the day. This week looks like rain with bad thunderstorms and possibly tornadoes this afternoon. Hope I get to finish it this week and it doesn't blow away!!!
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
coming along nicely
|
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
First little "pop" of a test fire. Once exhaust and wiring is all tidy, I'll take it for a test drive.
https://youtu.be/tdRV9wJUk7M |
Re: Project Mr. Green Jeans (now 5.3 LS turbo build!)
Clicked on the link but the video came up as private and wouldn't play? Tease!:lol:
|
All times are GMT -4. The time now is 07:11 PM. |
Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Copyright 1997-2022 67-72chevytrucks.com