The 1947 - Present Chevrolet & GMC Truck Message Board Network







Register or Log In To remove these advertisements.

Go Back   The 1947 - Present Chevrolet & GMC Truck Message Board Network > General Truck Forums > Engine & Drivetrain

Web 67-72chevytrucks.com


Reply
 
Thread Tools Display Modes
Old 08-11-2021, 06:53 AM   #1
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
06 chevy express codes

My van is at it again. It will throw code po430 after about 50 miles of driving and kick the check engine light on a short time after that the light will start flashing when it kicks the code for random misfire and will continue to flash in longer cycles. I have not noticed any reduction in power or rough idle. Only thing I have noticed is that my fuel mileage has dropped from 11 to 9 mpg.

Motor is a 6.0 and auto. Issue started right after I had the AC recharged and used it the 1st time. I have not used it since just trying to figure this out 1st.

I took it to a local shop the other day and they said I would need to take to dealer to figure it out. I suspect they just did not want to work on it.

Any ideas before I end up at the dealer?

Thanks
Richard
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Old 08-11-2021, 09:00 AM   #2
burnin oil
Registered User
 
Join Date: Jan 2013
Location: Eastern TN
Posts: 1,919
Re: 06 chevy express codes

Po430 is a cat efficiency code. A quick search says usual suspects are a bad cat or O2 sensor. I think I would check the plugs to see of you have a leaking injector then swap the o2 sensor if all looks good. Cheapest parts to more expensive.
burnin oil is offline   Reply With Quote
Old 08-11-2021, 10:14 AM   #3
kwmech
Senior Member
 
Join Date: Mar 2003
Location: Colfax-California
Posts: 8,355
Re: 06 chevy express codes

could be either sensor or actually a bad cat. (bank 2) You'll need voltage readings off of both sensors and possibly a laser temp gun
kwmech is offline   Reply With Quote
Old 08-11-2021, 06:52 PM   #4
AussieinNC
Moderator
 
AussieinNC's Avatar
 
Join Date: Jun 2017
Location: Cherryville, NC
Posts: 2,152
Re: 06 chevy express codes

Bank 2 is passenger side

Buy and change out both O2 sensors on that side....clear codes and drive for around 30 miles....

Nowadays, bad cats are pretty rare unless something strange has been happening with fuel...

Let us know the results...


__________________
Family and country before all others...

2006 Chevy Silverado (Daily Driver)
2012 Chevy Equinox

AussieinNC is offline   Reply With Quote
Old 08-14-2021, 08:01 AM   #5
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
Re: 06 chevy express codes

Sorry guys, I did not get any notifications that anyone had responded. Been super busy this week and just threw the van in the shop to take a look at it today. I had a friend come over and throw his new Snap on scanner on and it is also throwing PO300 random misfire which he was able to confirm it was on cylinders 5 & 6. He also showed it is throwing a PO101 for the MAF and it is way out of range . The van has close to 190K on it now so I am going to go ahead and purchase all 8 coil packs, new MAF sensor and all 4 O2 sensors. The plugs & wires has less than 6k miles on them since I replaced them.

I am kinda stuck with fixing this one since I found out yesterday from the boom manufacturer that GM products are no longer authorized to run these booms after 2007 model year due to GM changing center of gravity and adding traction control to the vans. Only other option would be switching to a Ford which means all new mounting kit for the boom and engine driven pump or buying a whole new rig. A new rig is 90K (not happening) and to swap the boom, buy the mounting kit and purchase another van (with all cost associated with registering the van) make it a no brainer for me to just rebuild what i have including a new motor if need be. Even if I have to replace the cats, it appears rock auto has everything for about $800.

The eone thing I have not liked with this van since dy one is no cruise control but I found out I can add it for roughly $400 so that is going to happen as well once I get these gremlins in order.
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Old 08-27-2021, 06:54 AM   #6
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
Re: 06 chevy express codes

Well, so far I have changed 7 out of 8 coil packs (#1 cyl I have yet been able to reach from either direction) The MAF sensor and 3 out of 4 O2 sensors The forward o2 on passenger side is froze and won't budge. May end up replacing the entire cat pipe from manifold to muffler since rock auto shows them available. I took it for a 100 mile round trip and the only time the check engine light comes on now and flashes is when under load like leaving a light or going up hill. Only code it is throwing now if the PO300 random misfire.
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Old 09-01-2021, 11:27 PM   #7
truckdude239
Senior Member
 
truckdude239's Avatar
 
Join Date: Sep 2005
Location: Lewisville, Nc
Posts: 10,216
Re: 06 chevy express codes

Have the intake gaskets been done on this yet? Very common and will set a p030p
__________________
David fuller
Ase Certified Mechanic
Click here to help support our board!!


1971 Chevy c-10 under going a 4.8l LSx swap

Build Thread http://67-72chevytrucks.com/vboard/s...d.php?t=421305

2007 Honda Accord my daily 145kmiles
2002 Honda Accord 4 door With 330k(sisters car)
2005 toyota Avalon 228k( brothers car)
2002 Sububran 5.3 245k
2000 Tahoe 5.3l 378

General manager for Marco's Carwash & lube
truckdude239 is offline   Reply With Quote
Old 09-02-2021, 06:38 AM   #8
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
Re: 06 chevy express codes

Quote:
Originally Posted by truckdude239 View Post
Have the intake gaskets been done on this yet? Very common and will set a p030p
The intake gasket has not been changed since I have owned the van. I will have to look into that as well.

Thanks
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Old 09-02-2021, 02:12 PM   #9
truckdude239
Senior Member
 
truckdude239's Avatar
 
Join Date: Sep 2005
Location: Lewisville, Nc
Posts: 10,216
Re: 06 chevy express codes

i would check that but you may very well have a cloged cat on bank 2
__________________
David fuller
Ase Certified Mechanic
Click here to help support our board!!


1971 Chevy c-10 under going a 4.8l LSx swap

Build Thread http://67-72chevytrucks.com/vboard/s...d.php?t=421305

2007 Honda Accord my daily 145kmiles
2002 Honda Accord 4 door With 330k(sisters car)
2005 toyota Avalon 228k( brothers car)
2002 Sububran 5.3 245k
2000 Tahoe 5.3l 378

General manager for Marco's Carwash & lube
truckdude239 is offline   Reply With Quote
Old 09-22-2021, 02:00 PM   #10
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
Re: 06 chevy express codes

I give up on the issues. It goes to the dealer tomorrow
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Old 10-05-2021, 07:36 AM   #11
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
Re: 06 chevy express codes

man what an ordeal this has been and still not done. Took van to dealer they gave estimate of $2100 to replace just the right side cats. Said it could double if the lefts ended up being restricted as well but they would not know until after changing the right side. I had to decline the work at that cost. Brought van back home. Found exact cat setup on rock auto and bought left side, right side, stainless muffler & tailpipe including next day shipping for $1400. This was last Thursday, everything was supposed to be here Friday and I would have the weekend to get it all on. Friday comes and everything shows up except for the left side cats, grrr. Finally find out they missed the baltimore transfer and did not get to Salisbury station until late Friday. no huge deal yet since they were open Saturday 10-2 I just went over and picked it up. I get back to the shop get the old system removed. Pull all the cats out of the boxes only to discover that the factory put a right side cat system in the left cat boxing so now I am sitting here with 2 right side cat assemblies. Have you ever tried to "talk" to someone at Rock Auto? After going thru their automated return system I was finally able to at least come up with an email address for them to explain the situation in greater detail. Someone actually answered on Sunday saying the new part would ship yesterday next day air and sorry for the issue. I emailed back to see if they could open the new box to verify that the part they are sending me matches the picture on the website to which they replied the warehouse will not do that. So the new part is supposed to be here today with a 50/50 shot of being the correct part this time. Based on this picture I am surprised this thing actually ran at all. I am just hoping it takes care of the issues.
Attached Images
    
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Old 10-05-2021, 03:53 PM   #12
cwcarpenter98
Senior Member


 
cwcarpenter98's Avatar
 
Join Date: Jan 2018
Location: Hickory Flat, GA
Posts: 4,419
Re: 06 chevy express codes

Wow, that's a bummer on the part problem. I ran into the same type of issue when I replaced some A/C components on my Dakota. I got a box for the dryer that had clearly been tossed around, left on a shelf for ages, and covered in dirt. Opened to find that the part was no where near what I should have received. Tried to call, but got nothing. Emailed with a picture of what was in the box and got the correct part sent at no charge, but yeah, it was frustrating.

I hope that your issue will be fixed after replacing those cats! Sweep all that dust up and put it back in the old, then take to the scrap yard to try to recoup some of the new
__________________
Christian Carpenter

1963 C10 - Frankentruck 283, 3 speed with overdrive
Overdrive wiring here
1963-ish truck bed trailer - Half-Wit

1981 C10 - Penny 305, th350

1995 Dodge Dakota Sport

"I'll put it simple: if you're going hard enough left, you'll find yourself turning right." - Doc Hudson
cwcarpenter98 is offline   Reply With Quote
Old 10-06-2021, 04:37 PM   #13
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
Re: 06 chevy express codes

Well the correct parts finally showed up today & I just got them installed. Took van for a short drive but did not want to get caught in the rain if it did break down. Seemed to run pretty good with a lot more power. I will test it out better tomorrow, have to make a 70 mile round trip which normally sets it into crazy check engine mode.
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Old 10-06-2021, 09:00 PM   #14
kwmech
Senior Member
 
Join Date: Mar 2003
Location: Colfax-California
Posts: 8,355
Re: 06 chevy express codes

That's why you use a temp gun on the cat.
kwmech is offline   Reply With Quote
Old 10-08-2021, 07:33 AM   #15
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
Re: 06 chevy express codes

Cats seem to have fixed the issue. just did a 250 mile round trip with no issues or lights. Even runs a little cooler on the temp gauge.
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Old 10-08-2021, 09:28 AM   #16
The Rocknrod
Moderator

 
The Rocknrod's Avatar
 
Join Date: Aug 2011
Location: China Spring, TX
Posts: 7,280
Re: 06 chevy express codes

Ya I had a problem with a return at Rock Auto also. Not ever using them again. It's not like it used to be there. Not user friendly at all.
The Rocknrod is offline   Reply With Quote
Old 10-08-2021, 09:29 AM   #17
cwcarpenter98
Senior Member


 
cwcarpenter98's Avatar
 
Join Date: Jan 2018
Location: Hickory Flat, GA
Posts: 4,419
Re: 06 chevy express codes

Party time!
__________________
Christian Carpenter

1963 C10 - Frankentruck 283, 3 speed with overdrive
Overdrive wiring here
1963-ish truck bed trailer - Half-Wit

1981 C10 - Penny 305, th350

1995 Dodge Dakota Sport

"I'll put it simple: if you're going hard enough left, you'll find yourself turning right." - Doc Hudson
cwcarpenter98 is offline   Reply With Quote
Old 10-08-2021, 09:59 AM   #18
richard2717
Equal opportunity joke ofender
 
richard2717's Avatar
 
Join Date: Oct 2011
Location: Eastern Shore of MD
Posts: 9,863
Re: 06 chevy express codes

For anyone that should need to contact Rock auto for issues the enail is service@rockauto.com they were pretty responsive once I obtained the address. I never found it on the website anywhere. I was doing a google search and came across it in a forum chat. even with everything shipping from 5 different warehouses it was still $3k cheaper than the dealer. I found out that these are made by magnaflow and on their site they were double the price of rock auto.
__________________
Members I have met.
Dually Jams, OlBlue60, ScottH, Tommyboy24, Dujobo, Warbucket, 2003 Silverado, Notsolo, my90k5, 6t727t2, Special-K ,Jack_71C10, tabarcus,72blazer_mud_bogger,pwdcougar,RSavage,EricSean,1Rippen6,invicta455,tennaragtop71,arks, Kendal,Bennett68C10, Perpendicular, Chainsawman, McGeesCustomMinis,ShortbedClayton,longblue72,6768chevylover,Tim71,Travisarmenta,Ol' Drippy,fleetmitch,georgieb51,Dave,bcnya2,Dadsburb
https://paypal.me/6772GMtruckparts
Most women like the strong, silent type… Fortunately for me, my wife prefers the out-of-shape, mouthy type.
richard2717 is offline   Reply With Quote
Reply

Bookmarks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -4. The time now is 09:30 AM.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Copyright 1997-2022 67-72chevytrucks.com